Zhongke automatic mixer uses advanced automation technology to support the mixer to complete complex operations such as automatic feeding, automatic water, automatic mixing, automatic unloading, etc. Automatic mixer is becoming more and more popular. What are its safety standards? Let Xiaobian tell you:

自動攪拌車的安全運用標準

Standard for safe operation of automatic mixer

1、自動攪拌車應施行二級漏電維護，上班前電源接通后，要仔細查看，經空車試轉認為合格，方可運用。

1. The secondary leakage maintenance shall be carried out for the automatic mixer. After the power supply is connected before going to work, it shall be checked carefully. It can only be used after the test run of the empty mixer is qualified.

試工作時應檢驗拌筒轉速是否合適，一般情況下，空車速度比重車(裝料后)稍快2~3轉，如相差較多，應調整動輪與傳動輪的比例。

During the trial work, it is necessary to check whether the rotating speed of the mixing drum is appropriate. Generally, the speed of the empty truck is slightly faster than that of the truck (after loading) by 2-3 revolutions. If there is a large difference, the ratio of the driving wheel and the driving wheel shall be adjusted.

2、自動攪拌車拌筒的旋轉方向應契合箭頭指示方向，如不符實，應更正電機接線。

2. The rotation direction of the mixing drum of the automatic mixer shall conform to the direction indicated by the arrow. If not, the motor wiring shall be corrected.

3、查看傳動離合器和制動器是否靈敏牢靠，鋼絲繩有無損壞，軌道滑輪是否杰出，周?chē)袩o(wú)妨礙及各部位的潤滑情況等。

3. Check whether the transmission clutch and brake are sensitive and reliable, whether the steel wire rope is damaged, whether the track pulley is outstanding, whether there are obstacles around and the lubrication of various parts.

4、自動攪拌車應設置在平整的方位，用方木墊起前后輪軸，使輪胎擱高架空，以免在開動時發生走動。

4. The automatic mixer shall be set in a flat position, and the front and rear axles shall be padded with square wood, so that the tire can be put on the elevated space, so as to avoid walking when starting.

5、當自動攪拌車混凝土拌和完畢或估計停歇1h以上，除將余料出凈外，使用石子和清水倒入抖筒內，開機滾動，把粘在料筒上的砂漿沖刷干凈后悉數卸出。

5. When the concrete of the automatic mixer has been mixed or it is estimated that it will stop for more than 1h, in addition to discharging the remaining materials, use stones and clear water to pour into the shaker, start the machine and roll it, wash the mortar stuck on the material cylinder and then discharge it.

料筒內不得有積水，以免料筒和葉片生銹。同時還應整理拌和筒外積灰，使機械保持清潔無缺。

There shall be no ponding in the barrel to avoid rusting of the barrel and blades. At the same time, the ash outside the mixing drum shall be cleaned to keep the machinery clean.

6、自動攪拌車開機后，常常注意拌和機各部件的工作是否正常。

6. After the automatic mixer is started up, it is often noted whether the components of the mixer work normally.

停機時，常常查看拌和機葉片是否打彎，螺絲有否打落或松動。

When stopping the machine, always check whether the mixer blades are bent and whether the screws are broken or loose.

7、下班后及停機不用時，應拉閘斷電，并鎖好開關箱，以確保安全。

7. After work and when the machine is not in use, the power shall be cut off and the switch box shall be locked to ensure safety.

關于自動攪拌車注意事項http://www.sansungmobile.cn/就先介紹到這里了，相信大家在實際的工作中會用到相關知識，如果您有這方面的需要，歡迎前來選購。

Notes on automatic mixer http://www.sansungmobile.cn/ I'm sure you will use the relevant knowledge in the actual work. If you have the needs in this regard, welcome to purchase.