商品混凝土水泥攪拌車發生故障時時候，若沒有及時將攪拌罐內的清理出來，時間一久將會凝固，會給我們帶來很大的經濟損失。那么你知道在緊急情況下如何清理水泥攪拌車內商品混凝土嗎？

When the commercial concrete cement mixer truck breaks down, if it is not cleaned out in time, it will solidify over time, which will bring us great economic losses. Do you know how to clean the commercial concrete in the cement mixer in case of emergency?

方法一

Method 1

1、準備好緊急驅動軟管，將故障水泥自上料攪拌車熄火，卸下液壓馬達上的高壓油管接頭。2、將救援車熄火，將其液壓馬達的高壓油管卸下，并與故障車上的對應接頭用緊急驅動軟管相連。3、發動救援車，將其操縱手柄撥至出料位置，故障車內的商品混凝土即被排出。4、緊急驅動完畢后，將驅動軟管卸下，并恢復兩車原狀。

1. Prepare the emergency drive hose, shut down the faulty cement from the loading mixer, and remove the high-pressure oil pipe connector on the hydraulic motor. 2. Turn off the rescue vehicle, remove the high-pressure oil pipe of its hydraulic motor, and connect it with the corresponding connector on the faulty vehicle with an emergency drive hose. 3. Start the rescue vehicle, turn its control handle to the discharge position, and the commercial concrete in the faulty vehicle will be discharged. 4. After the emergency drive, remove the drive hose and restore the two vehicles to their original state.

方法二

Method II

1、若個方法實行有困難，則必須采用以下方法，立即排出商品混凝土。

1. If the first method is difficult to implement, the following methods must be used to discharge the commercial concrete immediately.

2、在托輪和滾道之間放入木楔，以控制攪拌筒的旋轉，一定要注意安全;將發動機熄火，拆松液壓馬達的一根高壓油管，攪拌筒可自由旋轉，控制攪拌筒的旋轉，使維修孔轉到下部，然后打開維修孔，清理出筒內商品混凝土。此時一定要注意安全，商品混凝土排出完畢后，恢復商品混凝土水泥攪拌車原狀。

2. Put a wooden wedge between the supporting wheel and the raceway to control the rotation of the mixing drum, and pay attention to safety; Turn off the engine, disassemble a high-pressure oil pipe of the hydraulic motor, the mixing drum can rotate freely, control the rotation of the mixing drum, turn the maintenance hole to the lower part, and then open the maintenance hole to clean out the commercial concrete in the drum. At this time, attention must be paid to safety. After the commercial concrete is discharged, the original state of the commercial concrete cement mixer truck shall be restored.

3、緊急清理水泥自上料攪拌車內商品混凝土是我們每個水泥攪拌車司機都應該會的，在水泥攪拌車發生故障的時候，及時清理，將損失降到低。

3. Every driver of cement mixer truck should be able to urgently clean the commercial concrete in the cement self loading mixer truck. When the cement mixer truck breaks down, it should be cleaned in time to reduce the loss.

方法三

Method III

用“風炮”打碎凝結的混凝土，然后一點點鏟出來！罐體下部要割開一個口，加翻開一個原來就有用羅絲上緊的一個封蓋，這個蓋是讓有需求進去工作時翻開通風和緊急情況用來放料的。而在打罐過程中人在罐里面要通風，在裝料罐入口放臺風扇吹風進去。

Use the "air cannon" to break the set concrete, and then shovel it out bit by bit! An opening shall be cut at the lower part of the tank body, and a cover which was originally tightened with a screw shall be opened. This cover is used to open the air and discharge materials in case of emergency when it is necessary to enter the tank for work. In the process of canning, people should be ventilated inside the tank, and a fan should be placed at the inlet of the charging tank to blow in.

而“風炮”工作時會搞起灰塵，又要接上水管淋濕打碎的混凝土。把罐里面的再混凝土打碎鏟出以后再打割開部分焊接上，上回封蓋，裝滿水試下轉動能否正常，再少量裝料遞增看液壓機工作能否正常，一切正常即可以繼續運作了。

The "air cannon" will cause dust when it works, and it will be connected to the water pipe to wet the broken concrete. After the re concrete in the tank is broken and shoveled out, the cut part shall be welded, the upper cover shall be closed, the water shall be filled to test whether the rotation can be normal, and a small amount of loading shall be increased to see whether the hydraulic press can work normally. If everything is normal, it can continue to operate.

以上就是問題的相關介紹內容了，希望對您有所幫助，您可以關注我們網站www.sansungmobile.cn，了解咨詢更多詳細的信息，我們的客服人員也會為您提供好的服務！

The above is the relevant introduction of the problem. I hope it can help you. You can follow our website www.sdzkjf Cn, for more detailed information, our professional customer service staff will also provide you with good services!